RSS

Under the balcony frame

17 Jul
Under the balcony frame

So the next step to finishing off the deck is to offset the wall by boarding up the section under the back balcony. I have already started doing this as you can see in my previous post on the deck.

To be able to put the boards up, I need something to attach them to, so I have put a length of timber on either side of the metal supports for the awning. I put one on either side of the middle support and then one in the inside of each of the two other supports. I measured them to be exactly from the ground to the width of one decking board below the level of the balcony floor. This meant I could cap the whole thing with a decking board.

To attach the timber to the metal supports, I decided the best way was to use ‘tech screws’ which are specifically for metal. The ones I had left over from the roof of the awning were perfect, but a little short. Therefore I drilled the hole and then drilled a much larger hole (the size of the head of the screw) about halfway into the timber. This meant it would happily go into the metal, but would still hold the timber.

I also made sure the timber was a little bit wider than the metal to make sure that there was some air around it to breathe a bit. I also used timber the same width as the decking boards, this way it would nicely even up.

The next step was to cut a decking board the exact length to fit between the supports. This would be the capping to make the whole thing look neat and to avoid anything falling down behind the boards. I sat them in place to ensure they fit properly and then screwed them down once they were in place.

So, as you can see in the above picture, the part under the stairs needed to have a gap there to hold it in place. I figured that once the cross boards were there they would hold the side part in place so no further attaching would be required.

With the rest of that part set up, it’s time to finish off the side part under the stairs…

Advertisements
 
Leave a comment

Posted by on July 17, 2012 in Decking [COMPLETE]

 

Tags: , , , ,

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out /  Change )

Google+ photo

You are commenting using your Google+ account. Log Out /  Change )

Twitter picture

You are commenting using your Twitter account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s

 
%d bloggers like this: